fzr400 3tj firing order? is it 1234 starting from the left?

rickyr · Post by **rickyr** » Wed Sep 09, 2009 10:54 pm

fzr400 3tj firing order? is it 1234 starting from the left side when sitting on bike or am i wrong?

fzrtim · Post by **fzrtim** » Wed Sep 09, 2009 11:57 pm

Firing order is 1-2-4-3, 1 been the left cylinder when you are sitting on it!

Post by **Evilchicken0** » Thu Sep 10, 2009 5:35 pm

I though it was 1 3 2 4 oh well never mind

Post by **hunter** » Thu Sep 10, 2009 8:08 pm

it's 1342 from left to right,siting on the bike.

rickyr · Post by **rickyr** » Thu Sep 10, 2009 8:41 pm

thanks for the replys

i can get all caps on at 1243 but the bike dosnt run all that good number 3 will not gon onto the 2nd cyclinder from the left as its not long enough i thought maby i had the coils on the wrong way but if i reverse them then number 1 will not go on 2 the 1st cyclinder from the left side.

number 3 must go onto the 3rd or 4th cyclinders the other i dont no lol the best way the bike has run is 1234 but it didnt seem 2 want 2 rev over 8k this could be becasue of a few other things tho.

any one have a manuel they could check???

Post by **hunter** » Thu Sep 10, 2009 10:12 pm

The plug leads are numbered,and fit in order,No 1 left cyl.
No 2 2nd cyl
No 3 3rd cyl
No 4 outside right cyl.

ARn13 · Post by **ARn13** » Thu Sep 10, 2009 10:42 pm

Check out service manual downloads chapter 2 page 28, shows you a full diagram of coils and ht leads set up. wud paste it here but cant figure out how to

. Its on general section http://www.commline.com/FZR/400/MANUAL/" onclick="window.open(this.href);return false;

rickyr · Post by **rickyr** » Thu Sep 10, 2009 11:00 pm

i think thats for the older model but if its the same they mine is slightly different set up on that the number 3 is on the left side coil and the inside my number 3 is on the right side coil and is the out side of the 2

when i put them 1243 the bike is hard 2 start and when started runs awful when i put them 1234 the bike starts easy and runs alot better

Post by **Evilchicken0** » Thu Sep 10, 2009 11:13 pm

Oh ... god this really isn't a post for dyslexic's

There are 2 coils

Each coils fires Twice per revolution at top and Bottom (the bottom spark has nothing to ignite).

One coil works cylinders 1 and 4 (the outside ones)
The other coil works cylinders 2 and 3 (the middle ones)

As long as they're wired with the middles to one coil and the outers to the other it will either run or not.

Sounds like you've got a dodgy connection, probably with the plug cap. Unscrew them one by one cut the HT lead back by 5mm and screw the cap back on.

rickyr · Post by **rickyr** » Fri Sep 11, 2009 12:09 am

Evilchicken0 wrote:Oh ... god this really isn't a post for dyslexic's

There are 2 coils

Each coils fires Twice per revolution at top and Bottom (the bottom spark has nothing to ignite).

One coil works cylinders 1 and 4 (the outside ones)
The other coil works cylinders 2 and 3 (the middle ones)

As long as they're wired with the middles to one coil and the outers to the other it will either run or not.

Sounds like you've got a dodgy connection, probably with the plug cap. Unscrew them one by one cut the HT lead back by 5mm and screw the cap back on.

aye and thats the way i have it it works out at 1234 starting from the left side but i just asked make sure then people said it was 1243 and a few other ways etc...so then i was confused lol

aye il cut about 5mm of each of them for a new conection

fzr400 3tj firing order? is it 1234 starting from the left?

fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?

Re: fzr400 3tj firing order? is it 1234 starting from the left?